Product ID:AW HYDRAULIC OIL 10, CPS232942
MSDS Date:11/18/1989
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKYHZ

Emergency Phone: 800-457-2022

Info Phone: 800-582-3835

Cage: 0AHD1

Telephone: 800-582-3835

Cage: 4M745

ADDITIVES. (NO CAS# PROVIDED)

DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC ( OR

CAS: 64742-52-5

RTECS: PY8035000

DISTILLATES (PETROLEUM), HYDROTREATED LIGHT NAPHTHENIC (OR

CAS: 64742-53-6

RTECS: PY8036000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:DANGER! HARMFUL OR FATAL IF SWALLOWED.
EYE: THIS SUBSTANCE IS NOT EXPECTED TO CAUSE PROLONGED OR
SIGNIFICANT EYE IRRITATION. THIS HAZARD EVALUATION IS BASED ON THE
DATA FROM SIMILAR MATERIALS. SKIN: T HIS SUBSTANCE IS NOT EXPECTED
TO CAUSE PROLONGED OR SIGNIFICANT SKIN IRRITATION. THIS HAZARD
EVALUATION IS BASED ON DATA FROM SIMILAR MATERIALS. DERMAL
TOXICITY: THE SYSTEMIC TOXICITY OF THIS SUBSTANC E HAS NOT BEEN
DETERMINED. HOWEVER, IT SHOULD BE PRACTICALLY NON-TOXIC TO INTERNAL
ORGANS IF IT GETS ON THE SKIN. THIS HAZARD EVALUATION IS BASED ON
DATA FROM SIMILAR MATERIALS. INHALATION: THE SYSTEM IC TOXICITY OF
THIS (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS PETROLEUM BASE
OILS WHICH MAY BE REFINED BY VARIOUS PROCESSES INCLUDING SEVERE
SOLVENT EXTRACTION, SEVERE HYDROCRACKING OR SEVERE HYDROTREATING.
NONE OF THE OILS REQUIRE A CANCER WARNING UNDER OSHA HAZARD
COMMUNICATION STANDARD 29CFR 1910.1200. THESE OILS HAVE NOT BEEN
LISTED IN NATIONAL TOXICOLOGY PROGRAM ANNUAL REPORT (FEDERAL REGS)
Effects of Overexposure:HEALTH HAZARD (CONT'D): INHALATION: SUBSTANCE
HAS NOT BEEN DETERMINED. HOWEVER, IT SHOULD BE PRACTICALLY
NON-TOXIC TO INTERNAL ORGANS IF INHALED. THIS HAZARD EVALUATION IS
BASED ON DATA FROM SIMILAR M ATERIALS. INGESTION: SYSTEMIC TOXICITY
OF THIS SUBSTANCE HAS NOT BEEN DETERMINED. HOWEVER, IT SHOULD BE
PRACTICALLY NON-TOXIC TO INTERNAL ORGANS IF SWALLOWED. THIS HAZARD
EVALUATION IS BASED ON DATA F ROM SIMILAR MATERIALS. BECAUSE OF LOW
VISCOSITY OF THIS SUBSTANCE, IT CAN DIRECTLY ENTER THE LUNGS IF IT
IS SWALLOWED (THIS IS CALLED ASPIRATION). THIS CAN OCCUR DURING THE
ACT OF SWALLOWING OR WHEN V OMITTING THE SUBSTANCE. (SUPPL SAFETY)

First Aid:EYE: NO FIRST AID PROCEDURES ARE REQUIRED. HOWEVER, AS A
PRECAUTION, FLUSH EYES WITH FRESH WATER FOR 15 MINUTES. REMOVE
CONTACT LENSES IF WORN. SKIN: NO FIRST AID PROCEDURES ARE REQUIRED.
AS A PRECAUT ION, WASH SKIN THOROUGHLY WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. NOTE TO PHYSICIAN: INJECTION UNDER THE SKIN
OF MATERIALS SIMILAR TO THIS PRODUCT IS ASSOCIATED WITH ACCIDENTS
INVOLVING HIG H-PRESSURE EQUIPMENT. WHEN EJECTED FROM THIS TYPE OF
EQUIPMENT, THE MATERIAL CAN EASILY PENETRATE THE SKIN AND LEAVE A
SMALL, SOMETIMES BLOODLESS, PUNCTURE WOUND. YET, BECAUSE OF ITS
DRIVING FORCE, MA TERIAL INJECTED INTO A (TRANSPORT INFO)

Flash Point Method:COC
Flash Point:=140.C, 284.F
Autoignition Temp:Autoignition Temp Text:NDA
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FOR FIRES INVOLVING THIS MATERIAL, DO NOT
ENTER ANY ENCLOSED OR CONFINED FIRE SPACE WITHOUT PROPER PROTECTIVE
EQUIPMENT, INCLUDING NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NORMAL COMBUSTION FORMS CARBON DIOXIDE
AND WATER VAPOR AND MAY PRODUCE OXIDES OF SULFUR AND PHOSPHORUS.
INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.

Spill Release Procedures:STOP SOURCE OF LEAK OR RELEASE. CLEAN UP
RELEASES AS SOON AS POSSIBLE. CONTAIN LIQUID TO PREVENT FURTHER
CONTAMINATION OF SOIL, SURFACE WATER OR GROUNDWATER. CLEAN UP SMALL
SPILLS USING APPROPRIATE TE CHNIQUES SUCH AS SORBENT MATERIALS OR
PUMPING. WHERE FEASIBLE AND APPROPRIATE, REMOVE CONTAMINATED SOIL.
FOLLOW PRESCRIBED PROCEDURES FOR REPORTING AND RESPONDING TO LARGER
RELEASES.

Handling and Storage Precautions:READ AND OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. AVOID PROLONGED OR FREQUENTLY REPEATED SKIN CONTACT
WITH THIS MATERIAL. KEEP OUT OF REACH OF CHILDREN. DO NOT WELD,
HEAT OR DRILL CONTAINER. RESIDUE MAY IGNITE WITH EXPLOSIVE
VIOLENCE IF HEATED SUFFICIENTLY. CAUTION! DO (OTHER PREC)
Other Precautions:HNDLG/STOR (CONT'D): NOT USE PRESSURE TO EMPTY DRUM
OR EXPLOSION MAY RESULT. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN . NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE
CONCENTRATIONS , THE USE OF AN APPROVED RESPIRATOR IS RECOMMENDED
(MFR).
Ventilation:USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE
CONCENTRATIONS OF THIS MATERIAL BELOW THE RECOMMENDED EXPOSURE
STANDARD.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL SAFETY GOGGLES . NO SPECIAL EYE
(SUPP SAFETY)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . NO SPECIAL SKIN PROTECTION IS USUALLY NECESSARY. SKIN
CONTACT CAN BE MINIMIZED BY WEARING PROTECTIVE CLOTHING. (MFR)
Work Hygienic Practices:EYEWASH MEETING ANSI DESIGN CRITERIA .
Supplemental Safety and Health
SYNONYM: MASTER SPEED RED OIL. SIGNS/SYMPTOMS OF OVEREXPOS (CONT'D):
ONCE IN LUNGS, SUBSTANCE IS VERY DIFFICULT TO REMOVE & CAN CAUSE
SEVERE INJURY TO THE LUNGS & DEATH. PHYSICAL/CHEMICAL INFORMATIO N
(CONT'D): SOLUBILITY: SOLUBLE IN HYDROCARBON SOLVENTS. EYE
PROTECTION (CONT'D): PROTECTION IS USUALLY NECESSARY (MFR).

Boiling Pt:B.P. Text:NDA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.89 @ 15.6/15.6C
Viscosity:9 CST @ 40C (MIN.)
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE. (SUPP SFTY)
Appearance and Odor:PALE YELLOW LIQUID. NO ODOR SPECIFIED BY MFR .
Percent Volatiles by Volume:NA

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Hazardous Decomposition Products:NDA
Conditions to Avoid Polymerization:POLYMERIZATION WILL NOT OCCUR.

Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS. CONTACT LOCAL ENVIRONMENTAL
OR HEALTH AUTHORITIES FOR APPROVED DISPOSAL OF THIS MATERIAL.

Toxicological Information:EYE IRRITATION, SKIN IRRITATION, DERMAL
TOXICITY, RESPIRATORY/INHALATION, INGESTION: NO DATA AVAILABLE.
THESE HAZARD EVALUATIONS WERE BASED ON DATA FROM SIMILAR MATERIALS.
COMPOSITION COMMENT: BASED U PON INFORMATION REVIEWED TO DATE,
THISPRODUCT FITS THE ACGIH DEFINITION FOR MINERAL OIL MIST. THE
ACGIH TLV IS 5MG/M3, THE OSHA PEL IS 5MG/M3. THE PERCENT
COMPOSITIONS OF THE INGREDIENTS ARE GIVEN TO ALLOW FOR THE VARIOUS
RANGES OF THE COMPONENTS PRESENT IN THE WHOLE PRODUCT AND MAY NOT
EQUAL 100%.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THIS MATERIAL IS NOT EXPECTED TO PRESENT ANY ENVIRONMENTAL
PROBLEMS OTHER THAN THOSE ASSOCIATED WITH OIL SPILLS.

Transport Information:DOT SHIPPING NAME: NDA. DOT HAZARD CLASS: NDA.
DOT IDENTIFICATION NUMBER: NDA. FIRST AID (CONT'D): MATERIAL
INJECTED INTO FINGERTIP CAN BE DEPOSITED INTO PALM OF HAND. WITHIN
24 HRS, THERE IS USUALLY A GREAT DEAL OF SWELLING, DISCOLORATION &
INTENSE THROBBING PAIN IN THE AFFECTED PART. IMMEDIATE TREATMENT AT
SURGICAL EMERGENCY CENTER IS RECOMMENDED. INHALATION: SINCE
MATERIAL IS NOT EXPECTED TO BE AN IMMEDIATE INHALATION PROBLEM, NO
FIRST AID PROCEDURES ARE REQUIRED. INGESTION: IF SWALLOWED, GIVE
WATER/MILK TO DRINK & TELEPHONE FOR MEDICAL ADVICE. DO NOT MAKE
PERSON VOMIT UNLESS DIRECTED TO DO SO BY MEDICAL PERSONNEL. (STATE
INFO)

SARA Title III Information:SARA 311 CATEGORIES: IMMEDIATE (ACUTE)
HEALTH EFFECTS: NO. DELAYED (CHRONIC) HEALTH EFFECTS: NO. FIRE
HAZARD: NO. SUDDEN RELEASE OF PRESSURE HAZARD: NO. REACTIVITY
HAZARD: NO.
Federal Regulatory Information:ALL THE COMPONENTS OF THIS MATERIAL ARE
ON THE TOXIC SUBSTANCES CONTROL ACT CHEMICAL SUBSTANCES INVENTORY.
CARCINOGENICITY (CONT'D): NOR HAVE THEY BEEN CLASSIFIED BY THE
INTERNATIONAL AGENCY FOR RESE ARCH ON CANCER (IARC) AS;
CARCINOGENIC TO HUMANS (GROUP 1), PROBABLY CARCINOGENIC TO HUMANS
(GROUP 2A), OR POSSIBLY CARCINOGENIC TO HUMANS (GROUP 2B).
State Regulatory Information:N/P. TRANSPORT (CONT'D): IF MEDICAL ADVICE
CANNOT BE OBTAINED, THEN TAKE THE PERSON AND PRODUCT CONTAINER TO
THE NEAREST MEDICAL EMERGENCY TREATMENT CENTER OR HOSPITAL. NOTE TO
PHYSICIAN: INGESTION OF THIS PRODUCT OR SUBSEQUENT VOMITING CAN
RESULT IN ASPIRATION OF LIGHT HYDRDOCARBON LIQUID WHICH CAN CAUSE
PNEUMONITIS.